杨佩佩,吉娟,樊衍良,马成,姚燚杰,黄莹,潘昕,李革,陈航平,冯敏,吴传斌
YANG Peipei,JI Juan,FAN Yanliang,MA Cheng,YAO Yijie,HUANG Ying,PAN Xin,LI Ge,CHEN Hangping,FENG Min,WU Chuanbin

• 1:中山大学药学院
• 2:广州新济药业科技有限公司

摘要(Abstract)：

目的优化复合动植物蛋白乳化剂制备肠内营养乳的处方及工艺,并考察双蛋白乳化剂对营养乳的稳定作用。方法以酪蛋白酸钠和大豆分离蛋白作为乳化剂,采用高压均质法制备双蛋白乳,用正交设计法优化制剂处方,同时考察高压均质参数对乳剂粒径的影响,并对其形态、粒径、Zeta电位、离心稳定性和贮存稳定性进行评价。结果最佳处方为:油含量5%,酪蛋白酸钠1%,大豆分离蛋白1%;优化的均质参数为:一级阀均质压力400 bar,循环均质3次。制得的双蛋白乳平均粒径为(250.36±13.58)nm,多分散系数小于0.2,Zeta电位值为(-44.40±1.20)m V,离心和室温存放6个月后乳滴平均粒径未发生改变。结论以酪蛋白酸钠和大豆分离蛋白作为双蛋白乳化剂可制得稳定性良好的肠内营养乳。
OBJECTIVE This study is aimed to design and optimize a lipid emulsion based on double protein emulsifiers consisting of an animal protein and a plant protein for enteral nutrition and investigate the potential of double protein emulsifiers to prepare lipid emulsion with excellent stability. METHODS Lipid emulsion with double protein emulsifiers consisting of sodium caseinate( SC) and soy protein isolate( SPI) was prepared by high pressure homogenizer( HPH). The formulation was optimized by orthogonal design and the effect of HPH parameters on the average size of emulsion was investigated. The lipid emulsion was evaluated by the morphology,average size,polydispersion index( Pd I),centrifugal stability and storage stability. RESULTS The optimized formulation and HPH parameters were as follows: oil phase 5%,SC 1%,SPI 1%,and the HPH was performed with a first stage pressure of 400 bars,3 circles. The obtained lipid emulsion was( 250.36±13.58) nm in particle size with a Pd I of 0.2 and(-44.40±1.20) m V in zeta potential. Its average particle size didn't change after centrifugation and 6-month storage at room temperature. CONCLUSION Lipid emulsion based on double protein emulsifiers consisting of SPI and SC proved to have good stability for enteral nutrition.

关键词(KeyWords)： 肠内营养乳;双蛋白乳化剂;酪蛋白酸钠;大豆分离蛋白
enteral nutrition;double protein emulsifiers;sodium caseinate;soy protein isolate

Abstract:

Keywords:

基金项目(Foundation): 国家高技术研究发展技术[(863计划)2014AA022205]

作者(Author): 杨佩佩,吉娟,樊衍良,马成,姚燚杰,黄莹,潘昕,李革,陈航平,冯敏,吴传斌
YANG Peipei,JI Juan,FAN Yanliang,MA Cheng,YAO Yijie,HUANG Ying,PAN Xin,LI Ge,CHEN Hangping,FENG Min,WU Chuanbin

参考文献(References)：

• [1]Mc Clave S A,Martindale R G,Vanek V W,et al.Guidelines for the provision and assessment of nutrition support therapy in the adult critically ill patient[J].Journal of Parenteral and Enteral Nutrition,2009,33(3):277-316.
• [2]Gabor S,Renner H,Matzi V,et al.Early enteral feeding compared with parenteral nutrition after oesophageal or oesophagogastric resection and reconstruction[J].Br J Nutr,2005,93(4):509-513.
• [3]孙向东,李硕.蛋白质乳化作用与置换吸附探讨[J].食品工业科技,2012,33(16):405-408.
• [4]Mc Clements D J.Protein-stabilized emulsions[J].Current Opinion in Colloid&Interface Science,2004,9(5):305-313.
• [5]蔡志宁,赵谋明.蛋白质乳浊液体系稳定性研究进展[J].食品与发酵工业,2005,31(2):73-77.
• [6]庞广昌,陈庆森,胡志和,等.蛋白质的消化吸收及其功能评述[J].食品科学,2013,34(9):375-391.
• [7]张梦霞,周春霞,洪鹏志,等.罗非鱼蛋白-大豆蛋白混合体系乳化性的研究[J].安徽农业科学,2013,41(34):13369-13371,13417.
• [8]张峻菁,冯珊娜.正交设计法优选蒲桃中总黄酮的提取工艺[J].今日药学,2015,25(8):571-573.
• [9]Zhu ming,Jiang Sy Z,Xiu rong Wang,et al.A comparison of mediumchain and long-chain triglycerides in surgical patients[J].Annuls of Surgery,1993,217(2):175-184.
• [10]张超,韩丽,张芳,等.星点设计—效应面法优化苦参方的醇提工艺[J].现代中药研究与实践,2015,29(1):52-54,74.
• [11]苏健芬,郭喆霏,卓世添,等.用于全肠外营养的海豹油脂肪乳的处方工艺研究[J].广东药学院学报,2011,27(2):111-115.
• [12]黄永连,陈晓嘉,韩秋珍.氨基酸自动分析仪测定燕窝氨基酸组成[J].粮食流通技术,2016,23(12):99-103.
• [13]Boye J,Wijesinha Bettoni R,Burlingame B.Protein quality evaluation twenty years after the introduction of the protein digestibility corrected amino acid score method[J].The British journal of nutrition,2012,108(2):183-211.
• [14]Juliane Floury,Anne Desrumaux,Jérémie Lardières.Effect of highpressure homogenization on droplet size distributions and rheological properties of model oil-in-water emulsions[J].Innovative Food Science&Emerging Technologies,2000,1(2):127-134.
• [15]贾青慧,沈奇,陈莉.紫苏籽蛋白质与氨基酸的含量测定及营养评价[J].食品研究与开发,2016,37(10):6-9.
• [16]陆东林.乳蛋白质的氨基酸组成和氨基酸评分[J].新疆畜牧业,2014,(10):4-8.
• [17]尹宗伦,王靖,涂顺明,等.双蛋白工程与中华民族的强盛—以双蛋白工程振兴计划实现温总理的梦[J].中国食品学报,2007,7(1):1-5.
• [18]蒋建平,王靖.双蛋白开发战略与国民膳食结构最佳选择[J].农产品加工学刊,2006,10(11):52-54.